Now that the Dash Assembly is out of this 2007 Town Car it is time to start changing actuators. The image below is of the backside of the dash assembly. In the very center of the picture is the mode housing. If you look to the right edge you should notice a white round piece … Continue reading “2007 Lincoln Town Car HVAC Actuator Replacement”
Time to remove the dash assembly from this 2007 Lincoln Town Car. I had previously diagnosed a faulty Panel/Defrost Mode Actuator and removed the Steering Column Assembly. Now it was time to move on to the main dash assembly. There are two actuators on this vehicle that cannot be changed without first removing the dash … Continue reading “2007 Lincoln Town Car, Dash Removal Part 1”
This 2007 Lincoln Town Car came in with the complaint that sometimes the a/c air would not blow out of the face vent. Instead the air would flow from the defrost and floor vents. Sometimes the air would start flowing from the face vents a few seconds after turning the ignition on but would soon … Continue reading “2007 Lincoln Town Car A/C Does Not Blow Out Vents”
I recently had to remove the dash assembly from a 2007 Lincoln Town Car in order to replace several a/c actuators. I divided the repair into several articles due to the length of material and quantity of images. This part is dedicated to removing the steering column. The battery has already been disconnected. Removing the … Continue reading “2007 Lincoln Town Car Removing The Steering Column”
This 2006 Ford Expedition came in with the complaint that the transmission would shift through the gears and the torque converter solenoid would lock up below 25 mph. There was a shudder present at low speed due to the condition. The problem would also go away sometimes. A transmission shop and the local Ford dealership could … Continue reading “2006 Ford Expedition Transmission Shifts Too Soon”
This 2004 Lincoln town car came in with a rough run condition and codes P0300 and P0304 stored. the standard repair is new spark plugs, new spark plug boot kits and replace #4 coil assembly. I normally do not post tune up type repairs but I decided to do this one to see if there … Continue reading “2004 Lincoln Town Car, Multiple Misfires P0300 & P0304”
This 1993 Lincoln Town Car came in with the complaint that the right rear passenger power window stalls when going up. Works fine if you help the motor by lifting on the glass. Pretty cut and dry worn out torque pins in the power window motor. The first step in the repair is to remove … Continue reading “1993 Lincoln Town Removing The Right Rear Power Window Motor”