This 2005 GMC Sierra came in with the complaint that the speedometer does not work. In fact it was stuck at 55 mph when it was sitting in the shop key on engine off. This repair can apply to any one of up to seven gauges on 2003 through 2007 Classic series Cadillac, Chevrolet and … Continue reading “2005 GMC Sierra, Speedometer Sticks, Replacing Faulty Gauge Stepper Motors”
This 1995 GMC C1500 came in with the complaint that the air would blow from everywhere except the front vents. In using the controls, the air flow would adjust from the defrost to the floor. All other functions were okay as well. The mode actuator is located under the driver’s side of the dash, above … Continue reading “1995 GMC C1500, Air Will Not Blow Out The Vents”
This 2000 Chevrolet Suburban came in with the complaint that the instrument cluster does not work. I checked communication with my Tech 2 scan tool and found a communication problem with most modules. Including the instrument cluster. Since my scan tool would power up, I knew that I had power to the DCL and at … Continue reading “2000 Chevrolet Suburban, Instrument Cluster Does Not Work”
This is a list of procedures to replace the multiple actuators on General Motors Trucks and SUV’s from 1999 to 2009. These posts will apply to all of the Full Sized Trucks and SUV’s listed below. There may be slight differences between brands and trim levels. HVAC Calibration Procedure GM Trucks And SUV’s 2003 Chevrolet … Continue reading “Actuator Replacement GM Trucks and SUV’s 1999-2009”
I have separated the information that I have for the model years 1995 through 2012. This list covers the following model trucks, suv’s and vans that were made by General Motors but sold under the Buick, Cadillac, Chevrolet, GMC, Isuzu, Oldsmobile and Saab brands. The following list of vehicles use the same blower resistor and … Continue reading “Blower Motor Systems For GM Manufactured Trucks, SUV’s and Vans 1995-2012”
This 2005 Chevrolet Suburban came in with the complaint that the instrument cluster gauges do not work. I asked the customer how the problem had started and he told me that the speedometer has been acting up for a while. Recently all of the gauges stopped working at the same time. I connected my Tech … Continue reading “2005 Chevrolet Suburban Instrument Cluster Does Not Work”
This 2005 Chevrolet Tahoe came in with the complaint that the heater was working erratically. The customer stated that when she started the engine in the morning there would be no heat while idling and driving down her driveway. Once she had been driving at highway speed for several minutes heat would start coming out. When … Continue reading “2005 Chevrolet Tahoe, No or Erratic Heat”
This 2005 Chevrolet Tahoe came in with multiple complaints. Radiator cooling fans on with key off, dash warning lights on, gauges not working, door locks cycling, power windows not working and of course the battery will go dead if left sitting for any length of time. I had checked this Tahoe out a few weeks … Continue reading “2005 Chevrolet Tahoe, Multiple Complaints, Communication Faults”
This 2002 Chevrolet Malibu came in with a simple enough complaint. The power outlet in the dash did not work. Simple enough. I went to fuse number 34 in the underhood fuse box to check the fuse. Why is there a 2 amp fuse when there should be a 20 amp fuse? Why is it … Continue reading “2002 Chevrolet Malibu, Power Outlet Not Working”
This 2002 Chevrolet Tahoe had several complaints and this one is no fog lights. I connected my Tech 2 scan tool and checked some basic functions and found that the scan tool could turn on the fog lights. There was a codes stored for a park light malfunction. I checked wiring diagrams and found that … Continue reading “2002 Chevrolet Tahoe, Fog Lights Do Not Work”