This 2003 Chevrolet Express 2500 van with the 5.3 liter engine was towed into my shop as a no crank condition (starter does not work). There were two problems found. The IGN A fuse was blown in the underhood fuse box and the starter was no good. The starter had been replaced the day before … Continue reading “2003 Chevrolet Express Van-No Crank Condition”
This 2012 Chevrolet Express van came in with the complaint that the horn was stuck on and the the battery goes dead even though the horn has been disabled/disconnected. The customer could not accurately explain how the horn had been disconnected. I figured that the fuse or the relay must have been removed. The cover … Continue reading “2012 Chevrolet Express Van Horn Stuck On Battery Goes Dead”
This 2007 Chevrolet Express G1500 van came in with the complaint that the A/C would not work. Neither the blower nor the compressor would come on. Looking at a wiring diagram revealed that fuse number 10 in the interior fuse box supplies power to both the compressor and blower control portions of the HVAC system. … Continue reading “2007 Chevy Express G1500 Van, Fuse #10, HVAC Fuse Blows”
This 2000 Chevrolet Express van came in with the complaint that it had caught fire while sitting in a parking lot. Luckily the fire went out before any major damage was done. The source of the heat was the blower resistor and it’s harness connector but there was a lot more to the story than … Continue reading “2000 Chevrolet Express Blower Not Working, Resistor Caught Fire”
I have separated the information that I have for the model years 1995 through 2012. This list covers the following model trucks, suv’s and vans that were made by General Motors but sold under the Buick, Cadillac, Chevrolet, GMC, Isuzu, Oldsmobile and Saab brands. The following list of vehicles use the same blower resistor and … Continue reading “Blower Motor Systems For GM Manufactured Trucks, SUV’s and Vans 1995-2012”
This 1997 GMC Savana van has a problem with the blower speed dropping without the switch being moved. The resistor as you can see in the picture below is quite easy to get to. It is under the hood on the passenger side of the vehicle. If you would click on the picture below to … Continue reading “1997 GMC Savana Van, Changing The Blower Resistor”
2002 Chevrolet Astro Van was referred to me by two different shops because the battery would go dead quickly and at one of the shops the battery got very hot and the sub harness from the brake proportioning valve switch caught on fire. The battery had been replaced, the master cylinder was replaced and unfortunately … Continue reading “2002 Chevrolet Astro Van, Battery Went Dead”
This van came in with a complaint of the starter only clicks when trying to crank ,sometimes. In checking out the problem I noticed that when it did crank it cranked normally. I went to the starter and checked signals. The battery cable to the starter had 12 volts at all times, normal. The “S” … Continue reading “Intermittent Starter Operation 2002 GMC Savana Van”
Customer complaint of no stoplights or cruise control with park lights on. This repair applies to both Chevrolet Express vans and GMC Savanah vans from 1996 thru at least 2002. For replacement sockets please visit The Electric Connection Online Store or contact us by email at info@the-electric-connection.com The first picture shows the stoplight on without … Continue reading “2002 Chevrolet Express Van Stoplights Inop / Erratic”