1997 Ford Explorer, Low Oil Pressure On Gauge

This 1997 Ford Explorer came in with a complaint of low oil pressure reading on the gauge and sometimes the engine would rattle. Well this one is not an electrical problem but I thought I would share it with you anyways. The first thing I did was to check the oil to make sure there … Continue reading “1997 Ford Explorer, Low Oil Pressure On Gauge”

1994 Ford Ranger, No Low Beam Headlights

This 1994 Ford ranger came in with no low beam headlights and an owner with no money needing at least low beam headlight operating. He stated that he he could deal with no high beams. The first thing that I did was to confirm that there was no power on the red/black wire at the … Continue reading “1994 Ford Ranger, No Low Beam Headlights”

1993 Ford Explorer, Battery Goes Dead

This 1993 Ford Explorer came in with the complaint that the battery goes dead and both the battery and the alternator have been replaced. Believe it or not this is how it came in. I wonder what could be the problem? Maybe some faulty cable connections? Well this is strange the battery terminal on the … Continue reading “1993 Ford Explorer, Battery Goes Dead”

2001 Ford Explorer No Stoplights

The customer complaint on this 2001 Ford Explorer was that the lower stoplights did not work. The CHMSL (center high mounted stop light) did work so that indicated that the stoplight fuse and the stoplight switch were both okay. I tilted the steering wheel up and down while depressing the brake pedal and the lower … Continue reading “2001 Ford Explorer No Stoplights”

2003 Ford Explorer Right Rear Turn Signal Inop

2003 Ford Explorer with the right rear turn signal inop. The right stoplight also was not working. Checked the bulb and socket in the rear and all checked okay except no power to right rear socket. As this is a common problem on Ford Explorer, Expeditions, Excursions, E Vans and F Trucks with tilt wheel … Continue reading “2003 Ford Explorer Right Rear Turn Signal Inop”

2003 Ford Explorer Door Ajar Light Stays On

This 2003 Ford Explorer came in with several complaints; the door ajar light stays on with the doors closed and the engine running, the dome and puddle lights stay on for ten minutes after exiting the vehicle, when locking the doors the doors will lock then unlock on their own and the alarm will go … Continue reading “2003 Ford Explorer Door Ajar Light Stays On”

Replacing Torque Pins In Ford Power Window Motor

It was and still is very common for the torque pins inside Ford and some Chrysler power window motors to fail. The following instructions are for repairing the motor once it is out of the door. A Ford motor is being shown. Chysler motors are similar but the gears are installed backwards. Remove the single … Continue reading “Replacing Torque Pins In Ford Power Window Motor”

2001 Ford Ranger, Fuse #2 Blows

2001 Ford Ranger with automatic transmission came in with fuse #2 in the interior fuse block blowing for the customer daily. Customers main complaint was that the a/c would stop blowing when the fuse would blow. Inserted fused jumper wire that uses ATO/ATC fuses. Cheaper fuses to blow and can access wiring to do amp … Continue reading “2001 Ford Ranger, Fuse #2 Blows”