This 2002 Ford Explorer came in with the complaint that the engine would run poorly or not at all. The customer stated that he was able to start the engine only after installing a new set of spark plugs. There were multiple codes stored in the PCM; P0113, P0123, P0453, P0708 and P1289. Some of … Continue reading “2002 Ford Explorer, No Run / Poor Run Condition”
This 2006 Ford Expedition came in with the complaint that the transmission would shift through the gears and the torque converter solenoid would lock up below 25 mph. There was a shudder present at low speed due to the condition. The problem would also go away sometimes. A transmission shop and the local Ford dealership could … Continue reading “2006 Ford Expedition Transmission Shifts Too Soon”
This 1997 Ford Explorer came in with the complaint that the dome lights would stay on with all of the doors closed. I tried using one of my scan tools to look at data for the door ajar switches but was only able to see the information for the driver’s door and the passenger front … Continue reading “1997 Ford Explorer, The Interior Lights Stay On”
This is the last part of this repair article. The only aggravating part of this repair is the antenna cable. In order to pull the passenger side of the dash out far enough the cable has to be disconnected from the dash at two locations. It is held to the dash with push pin retainers … Continue reading “1999 Ford F150, Replacing Broken Blend Air Door, Part Three”
This is the second part of this repair to see the first part please click here. Moving to the driver’s side of the vehicle the finish panel that covers the sides and top edge of the steering column opening needs to be removed. It will pull loose by grabbing the lower edges and pulling it … Continue reading “1999 Ford F150, Replacing Broken Blend Door, Part Two”
I had already determined that the blend air door was broken in this 1999 Ford F150. There are some hacked up ways of changing this door and if that is what you are looking for this article is not for you. Although there are a lot of steps involved in replacing the broken blend air … Continue reading “1999 Ford F150, Replacing Broken Blend Door, Part One”
This 2002 Ford F150 came in with the complaint that the battery would go dead overnight. After the basics of checking the battery and alternator, I disconnected the negative battery cable and installed my Fluke multimeter in series between the negative battery post and the negative battery cable. I set the meter to read DC … Continue reading “2002 Ford F150, Battery Goes Dead Overnight”
This 1993 Ford Escort came in with the unusual complaint that the transmission would not shift with the tail/park lights on. From experience it seemed like it would be a faulty ground. I checked all of the grounds under the hood and all were okay. Since my faulty ground thoughts had not panned out I … Continue reading “1993 Ford Escort, Transmission Will Not Shift With The Tail Lights On”
This 2000 Ford F350 with the 7.3 liter diesel engine came in with the complaint that the a/c works sometimes. It seemed to work okay when a cold engine was started but as the engine warmed up the a/c would stop cooling. This one was easy enough to diagnose just by looking at the air … Continue reading “2000 Ford F350, A/C Not Cold Sometimes”
This 2009 Mercury Grand Marquis came in with the complaint the air conditioner would only blow air through the defroster vents. Rarely would air come out of the face vents. This is a common problem and can be expensive to repair. A work around, of sorts, is to manually drop the blower speed to the … Continue reading “2009 Mercury Grand Maquis, Air Will Not Blow Out Of Face Vents”