In the process of developing this repair and repair articles I have encountered a fair amount of grief from fellow professional technicians. Originally I posted an abbreviated version on a network that I belong to in hopes of providing a valuable procedure for both my fellow mechanics and their customers. I realize that it is … Continue reading “2011 Ford Expedition Replacing The Driver’s Side Temperature Door Actuator in Under 2 Hours Part 4”
The other epiphany that I had while thoroughly investigating this process was that I could get to the one hidden screw if the passenger side of the floor duct was gone. Then I thought how could it best be removed without disturbing anything else? I could cut it off with a saw but then what? … Continue reading “2011 Ford Expedition Replacing The Driver’s Side Temperature Door Actuator in Under 2 Hours Part 3”
Now that the seats and center console are out of the way it is time to start removing the metal brackets.There is a bracket that holds the wiring harness to the main frame. In order to get the wiring out of the way the connector body from the front harness needs to be removed from … Continue reading “2011 Ford Expedition Replacing The Driver’s Side Temperature Door Actuator in Under 2 Hours Part 2”
This 2011 Ford Expedition came in with the complaint that the driver’s side vents were stuck on heat. Since this truck has rear floor vents under the seats as shown below, the seats have to be removed from the vehicle. The plastic trim covers unsnap from the seat brackets to reveal the attaching bolts. The … Continue reading “2011 Ford Expedition Replacing The Driver’s Side Temperature Door Actuator in Under 2 Hours Part 1”
This 2003 Ford F150 came in with the complaint that the odometer works sometimes and sometimes it does not. The customer stated that it rarely works now. As you can see in the next picture it was not working when it came in. I have done a few of these in the past and have been … Continue reading “2003 Ford F150, Odometer Works Sometimes”
This 1988 Ford F250 Came in with the complaint that the battery would go dead while sitting overnight. As soon as the truck was dropped off I checked the alternator and confirmed that it was not charging properly. It had excessive ac ripple voltage. This would not explain the battery going dead overnight but it … Continue reading “1988 Ford F250 Pickup, Battery Goes Dead While Parked”
This 2006 Ford Expedition came in with the complaint that the transmission would shift through the gears and the torque converter solenoid would lock up below 25 mph. There was a shudder present at low speed due to the condition. The problem would also go away sometimes. A transmission shop and the local Ford dealership could … Continue reading “2006 Ford Expedition Transmission Shifts Too Soon”
This 1997 Ford Explorer came in with the complaint that the dome lights would stay on with all of the doors closed. I tried using one of my scan tools to look at data for the door ajar switches but was only able to see the information for the driver’s door and the passenger front … Continue reading “1997 Ford Explorer, The Interior Lights Stay On”
This is the last part of this repair article. The only aggravating part of this repair is the antenna cable. In order to pull the passenger side of the dash out far enough the cable has to be disconnected from the dash at two locations. It is held to the dash with push pin retainers … Continue reading “1999 Ford F150, Replacing Broken Blend Air Door, Part Three”
This is the second part of this repair to see the first part please click here. Moving to the driver’s side of the vehicle the finish panel that covers the sides and top edge of the steering column opening needs to be removed. It will pull loose by grabbing the lower edges and pulling it … Continue reading “1999 Ford F150, Replacing Broken Blend Door, Part Two”