2007 Chevrolet Tahoe LT, LBEC2 Fuse #75 Blows

This 2007 Chevrolet Tahoe LT came in with the complaint that the LBEC2 fuse would blow as soon as it was installed. The owner had tried several with the same result. The two symptoms that the owner noticed that pointed them towards a blown fuse was that the power windows and rear HVAC unit did … Continue reading “2007 Chevrolet Tahoe LT, LBEC2 Fuse #75 Blows”

GM “C/K” & “S/T” Vehicles, HVAC Recalibration Using a Tech 2 Scan Tool

It Recently came to my attention that some of my readers wanted to see how to perform an actuator recalibration using a Tech 2 scan tool. The pictures are dark and they are best viewed in low light conditions. Connect the scan tool to the DLC and turn the ignition on. After entering the year,make, … Continue reading “GM “C/K” & “S/T” Vehicles, HVAC Recalibration Using a Tech 2 Scan Tool”

2005 Chevrolet Silverado, Adding Factory Cruise Control

This 2005 Chevrolet Silverado came in with the complaint that it did not have cruise control. The customer, whom I have known for a long time, asked if I thought cruise control could be added to his truck. I was not sure. He stated that he had found several references to doing just that with … Continue reading “2005 Chevrolet Silverado, Adding Factory Cruise Control”

2006 GMC Yukon, P0449

This 2006 GMC Yukon came in with the Service Engine Soon (SES) light on and a code P0449 stored in the PCM memory. This test should be done on the vehicle but I could not figure a way to o the test and position everything for a good picture. So you will just have to … Continue reading “2006 GMC Yukon, P0449”

Actuator Replacement GM Trucks and SUV’s 1999-2009

This is a list of procedures to replace the multiple actuators on General Motors Trucks and SUV’s from 1999 to 2009. These posts will apply to all of the Full Sized Trucks and SUV’s listed below. There may be slight differences between brands and trim levels. HVAC Calibration Procedure GM Trucks And SUV’s 2003 Chevrolet … Continue reading “Actuator Replacement GM Trucks and SUV’s 1999-2009”

2002 Chevrolet Tahoe, Fog Lights Do Not Work

This 2002 Chevrolet Tahoe had several complaints and this one is no fog lights. I connected my Tech 2 scan tool and checked some basic functions and found that the scan tool could turn on the fog lights. There was a codes stored for a park light malfunction. I checked wiring diagrams and found that … Continue reading “2002 Chevrolet Tahoe, Fog Lights Do Not Work”

2005 GMC Sierra, Air Blows Only From Defroster Vents

This 2005 GMC Sierra came in with the complaint that the air will only flow from the defroster vents, regardless of where it is commanded to. This Sierra has auto a/c controls and no floor mounted center console. Of course the customer brought the truck in, knowing that I had to lay under the driver’s … Continue reading “2005 GMC Sierra, Air Blows Only From Defroster Vents”

2004 Chevrolet Silverado, Changing The Passenger Side Blend Door Actuator, B0424

This 2004 Chevrolet Silverado came in with a faulty passenger side blend door actuator. In the last post I got you to this point. If you have not yet read that post please click here. Now that the dash cover is off and you can see the actuator, but you still cannot get to it. … Continue reading “2004 Chevrolet Silverado, Changing The Passenger Side Blend Door Actuator, B0424”

2003 Chevrolet Silverado, Changing the Mode Actuator, Code B0263

This 2003 Chevrolet Silverado came in with the air flow stuck on defrost. A simple diagnosis of a code B0263 found a faulty mode actuator.  This repair applies to 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, and 2011 Chevrolet Avalanche, Silverado, Suburban and Tahoe. It also applies to Cadillac Escalade, GMC Sierra and Yukon … Continue reading “2003 Chevrolet Silverado, Changing the Mode Actuator, Code B0263”

2003 Chevrolet Silverado, A/C Leaks

This 2003 Chevrolet Silverado had come in about a month earlier, on a Friday afternoon and the customer wanted the system cold for a trip he was going on. The system had a low refrigerant charge. I added dye and oil, vacuumed it down and recharged the system. I advised the customer to come back … Continue reading “2003 Chevrolet Silverado, A/C Leaks”